Ethyl Ether (60-29-7)
Ethyl Ether is a volatile organic compound with CAS Registry Number 60-29-7. Under the OSHA air contaminants standard (29 CFR 1910.1000), its Permissible Exposure Limit (PEL) — the legal 8-hour time-weighted average (TWA) for general industry — is 400 ppm. The principal target organs are the CNS; respiratory tract, and workplace air is sampled and analyzed by NIOSH 1610.
Exposure Limits at a Glance
| Limit | Value | Basis |
|---|---|---|
| OSHA PEL (8-hr TWA) | 400 ppm | 29 CFR 1910.1000 |
| NIOSH REL | See note below | NIOSH Pocket Guide |
| Hazard Class | Volatile Organic Compound | VOC |
| Target Organs | CNS; respiratory tract | NIOSH / OSHA |
| Sampling Method | NIOSH 1610 | NIOSH Manual of Analytical Methods |
NIOSH REL note: TWA values in the ppm range; NIOSH RELs are frequently 10x stricter than the OSHA PEL. The REL is a non-regulatory recommendation; where a NIOSH REL exists it is typically more protective than the OSHA PEL.
How It Enters the Body & Health Effects
Exposure to Ethyl Ether is assessed against the CNS; respiratory tract — the organ systems most consistently affected in occupational studies. Employers must ensure no employee’s 8-hour TWA exceeds the 400 ppm PEL, and must use engineering controls, work practices, and — where required — respiratory protection to keep exposures at or below that level.
- Hazard class: Volatile Organic Compound. VOC-class agents are managed with the hierarchy of controls (elimination, substitution, engineering controls, administrative controls, then PPE).
- Monitoring: collect personal air samples in the breathing zone and submit them under NIOSH 1610 for laboratory analysis.
- Medical surveillance: consult the OSHA substance-specific standards and the NIOSH Pocket Guide when the target organs are the CNS; respiratory tract.
Sampling & Compliance Notes
- Determine whether the exposure is a full-period 8-hour TWA or a short-term / ceiling scenario. Ceiling and STEL excursions apply to several VOC-class agents regardless of the 8-hour average.
- Calibrate personal sampling pumps before and after each shift and record flow rates; method NIOSH 1610 specifies media, flow, and analysis.
- Compare analytical results to the OSHA PEL of 400 ppm and the NIOSH REL. Document the higher of the two for internal exposure-control targets.
- Where the PEL includes a “skin” notation, dermal absorption can contribute to the dose — glove selection and hygiene facilities are part of compliance.
Frequently Asked Questions
What is the OSHA PEL for Ethyl Ether?
The OSHA Permissible Exposure Limit (8-hour TWA) for Ethyl Ether is 400 ppm.
What is the CAS number for Ethyl Ether?
The CAS Registry Number for Ethyl Ether is 60-29-7.
What are the target organs for Ethyl Ether?
The primary target organs are the CNS; respiratory tract.
How do you measure Ethyl Ether in workplace air?
Use NIOSH analytical method NIOSH 1610 for air sampling and laboratory analysis.
What hazard class is Ethyl Ether?
It is classified here as a Volatile Organic Compound (VOC).